​​Why did your LED screen suddenly become black? ​ ​
You must have seen LED billboards that suddenly black screens in shopping malls, or large stage screens that flash at concerts. Data shows that among the national LED display failure cases in 2025, 42% of the damage occurred in the first three years of use. A screen that is nominated to be used for 10 years, why do some people scrap it after 5 years? Today we will explore the "lifetime mystery" that will not be explicitly mentioned in this industry.

Theoretical lifespan ≠actual lifespan

Many businesses will throw out the gimmick of "theoretical life span 100,000 hours", which can be used for 11 years in total. But just like the difference between the fuel consumption of a car watch and the actual fuel consumption, the moisture here is very large. To give a real example: the indoor screen with the same P3 spacing can last for 8 years when installed in an air-conditioned room, but may have a color difference in the kitchen of the hot pot restaurant for 2 years.

​​Key parameter comparison table​​

Three lifespan killers

According to industry reports, these three pitfalls have caused 90% of newbies to spend more money:

​​1. Cut corners on raw materials​​

• ​​Lamp beads​​: The lifespan of imported Japanese chips is three times that of domestic low-end products
• ​​Power supply module​​: The failure rate of miscellaneous power supplies is 8 times that of military-grade
• ​​Heat dissipation design​​: The screen without the common-shaking drive technology, the internal temperature can reach 80 in summer℃

​​2. Hard damage to the use environment​​
A restaurant owner installed the outdoor screen in the kitchen exhaust vent, and the oil stains caused the screen brightness to decrease by 40% in half a year. Remember these red lines:

• ​​temperature​​: Over 50℃ will accelerate the aging of lamp beads (such as Xishao glass curtain wall)
• ​​humidity​​: The seafood market screen must be equipped with IP65 waterproof grade
• ​​dust​​: The surrounding area of the construction site must be cleaned every quarter, otherwise the heat dissipation hole will be blocked

​​3. Maintenance misunderstanding​​
The most outrageous operation I have ever seen is to wipe the screen with dishwashing detergent – acidic cleaners can corrode the coating. The correct posture is:

• Use a soft brush to remove dust every week
• Make grayscale corrections every quarter (especially stage screens)
• Replace the cooling fan filter once a year

Hidden tips for extending life

Don’t be fooled by merchants to buy the most expensive products. These practical skills can make ordinary screens fight for three more years:

​​Brightness adjustment secret​​
The indoor screen is enough to open to 800cd/m² during the day, and it is more clear and power-saving when it drops to 300cd/m² at night. There is a shopping mall that uses smart photosensitive systems, saving 170,000 yuan in electricity bills and zero screen attenuation.

​​Installation Pit Avoidance Guide​​

• Avoid air outlet of the air conditioner (temperature difference causes deformation of the PCB board)
• More than 1.5 meters above ground (splash-proof + best viewing height)
• The distance between the control room is ≤30 meters (the super-long signal line needs to be added with a repeater)

​​Repair cost comparison​​

Self-question: 5 questions that Xiaobai cares most

​​Q: How long does it take to open the screen every day? ​ ​
A: The mall recommends that the screen should be closed for 2 hours a day and heat dissipation should be dissipated for ≤18 hours a day. There is a theater that opened the screen one hour before the opening, and closed the screen 30 minutes after the end of the show. It has been used for 7 years and has not been overhauled.

​​Q: Is the second-hand screen worth buying? ​ ​
A: Look at the remaining life of the lamp bead! Use a grayscale tester to measure the attenuation value, and pass directly to exceed 30%. Some merchants sold the refurbished screens of KTV as new products, which cheated countless people.

​​Q: Do you need to unplug the power supply on thunderstorms? ​ ​
A: Must be! Last year, 37 screens were penetrated by lightning during a typhoon, and the maintenance fee was enough to buy 3 new screens. The money you can't save on installing lightning protection modules.

​​Q: What to do if the color blocks appear on the screen? ​ ​
A: Check the signal line interface first (80% of it is poor contact). Never disassemble the module yourself, as static electricity will burn the driver IC.

​​Q: Which one has a longer life, a rental screen or a engineering screen? ​ ​
A: The aluminum-magnesium-zinc box of the rental screen can be disassembled and installed 2,000 times, but the life of the lamp bead is 15% shorter than that of the fixed screen. Select leasing for short-term activities, and select project payments for long-term fixed projects.

​​Editor's opinion​​
Don’t believe those nonsense of “lifetime warranty”. It is really reliable to write “five-year package replacement lamp beads” by regular manufacturers. The most conscientious contract terms that have ever been seen are "doing school corrections once a year for free", which is a supplier that allows you to not change screens for ten years. Next time I saw the merchant boasting about his life span, I asked him directly if he dared to sign the compensation clause for brightness decay - to ensure that he shut up immediately.

for more product information and pricing, please contact us .